Valorization Capacity of Slaughterhouse Waste in Biogas by a Tarpaulin Digester in Dakar, Senegal
American Journal of Environmental Protection
Volume 8, Issue 1, February 2019, Pages: 22-30
Received: Feb. 11, 2019;
Accepted: Mar. 15, 2019;
Published: Apr. 3, 2019
Views 103 Downloads 21
Haroun Ali Adannou, Department of Physics, Faculty of Science and Technology, Cheikh Anta Diop University of Dakar, Dakar, Senegal; Department of Chemical Engineering, National Institute of Petroleum of Mao, Mao, Chad
Saka Goni, Department of Physics, Faculty of Science and Technology, Cheikh Anta Diop University of Dakar, Dakar, Senegal; Department of Industrial Engineering and Maintenance, Polytechnic University of Mongo, Mongo, Chad
Etoungh Dimitri Manga, Department of Science, Charles Gerhardt Institute, University of Montpellier, Montpelier, France
Mamadou Simina Drame, Department of Physics, Faculty of Science and Technology, Cheikh Anta Diop University of Dakar, Dakar, Senegal
Lamine Ndiaye, Department of Physics, Faculty of Science and Technology, Cheikh Anta Diop University of Dakar, Dakar, Senegal
Kharouna Talla, Department of Physics, Faculty of Science and Technology, Cheikh Anta Diop University of Dakar, Dakar, Senegal
Aboubakar Chedikh Beye, Department of Physics, Faculty of Science and Technology, Cheikh Anta Diop University of Dakar, Dakar, Senegal
The recycling of waste into biogas inevitably occurs in hermetically sealed enclosures called bio-digester. Our study focuses on the recovery capacity of slaughterhouse waste by a tarpaulin bio-digester installed at the Dakar abattoir with a capacity of 4000m3 including a digester of 2500m3 and a gas meter of 1500m3. During our work, we have tried to understand the primordial factor favoring the obtaining of biogas in quantity. The studied system being in industrial size, the water retention time was programmed over 40 days according to the data of the company and according to the characteristics of the substrate, the pH was observed, and the temperature set on a mesophilic range. We have noticed that the considerable increase in wastewater (blood + wash water) for a minimal amount of rumen content is favorable to a better biogas yield. It shows that the content of our biogas consists mainly of CH4, CO2, O2, and H2S measured using a Severin Multitec 540 Device for the analysis of biogas in the field. (Quality feature on 1m3 of biogas produced). The biogas is then purified and used to power a cogeneration engine, generating electricity and heat. The implementation of this digester has made it possible to solve an environmental problem related to the waste and the valorization of the latter as essential energy for the study system.
Haroun Ali Adannou,
Etoungh Dimitri Manga,
Mamadou Simina Drame,
Aboubakar Chedikh Beye,
Valorization Capacity of Slaughterhouse Waste in Biogas by a Tarpaulin Digester in Dakar, Senegal, American Journal of Environmental Protection.
Vol. 8, No. 1,
2019, pp. 22-30.
Afilal Mohamed Amine, Elasri Ouahid, El Farh Larbi and Elaiche Hayat. Technical study of biogas production by an experimental bioreactor. Journal of Chemical and Pharmaceutical Research, 7(5):1005-1012 2015.
Biomethane Production from Animal Debris, Biomass Laboratory, Renewable Energy Development Center, B. P. 62, Observatory Road, Bouzaréah, Algiers. Rev. Energ. Ren.: Production and Valorisation. Biomass, 103-108, (2001) Production de Biométhane à Partir des Déjections Animales, Laboratoire de Biomasse.
M. E. Afilal, O. Elasri, Z. Merzak Organic waste characterization and evaluation of its potential biogas J. Mater. Environ. Sci. 5 (4) 1160-1169 ISSN: 2028-2508 CODEN: JMESCN (2014).
Afilal M. E., Auriol M., Filali-Meknassi Y. Chapter of the book "Renewable energies in Morocco - The debate is launched". UNESCO, 196 pp ISBN: 9954-8068-2-2. (2009).
M. DUPONT Nicolas valorization of the biogas of fermentation: catalytic combustion thesis university Claude Bernard Lyon 1 doctoral school of chemistry n ° of order 81-2010 year 2010.
A. Tahri, M. Djaafri, M. Khelafi, S. Kalloum and F. Salem Improving the yield of biogas production by co-digestion of organic waste (abattoir and poultry waste) Research Unit Renewable Energy in Saharan Environment, URERMS Renewable Energy Development Center, 01000, Adrar, Algeria. Renewable Energies Review SIENR'12 Ghardaia (2012) 375 – 380.
Document, Incineration of Waste and Public Health: Review of Recent Knowledge and Risk Assessment, ADEME, 1999.
S. Kalloum, M. Khelafi, M. Djaafri, A. Tahri and A. Touzi, Study of the influence of pH on the production of biogas from household waste. Renewable Energy Research Unit in Saharan Environment B. P. 478, Reggane Road, 01000 Adrar. Renewable Energies Review Vol. 10 N ° 4 (2007) 539 – 543.
Club Biogaz / ARENE Ile-de-France towards the energy autonomy of the territories. Methanization and biogas, a path for the future March 2012.
Zemene Worku, Seyoum Leta. Anaerobic Digestion of Slaughterhouse Wastewater for Methane Recovery and Treatability. International Journal of Sustainable and Green Energy. Vol. 6, No. 5, 2017, pp. 84-92. doi: 10.11648/j.ijrse.20170605.13.
O. Akinro, I. B. Ologunagba, and O. Yahaya (2009). Environmental implications of unhygienic operation of a city abattoir in Akure, Western Nigeria, ARPN Journal of Engineering and Applied Sciences, vol. 4, no. 9, pp. 311–315.
Lopez-Lopez A, De la Barrera-Fraire J, Vallejo-Rodriguez R, Barahona-Argueta C (2008) Comparative study between a physical-chemical process and a biological one to treat trace residual water. Interscience 33: 490-496.
D. I. Masse´ and L. Masse (2000). Treatment of slaughterhouse wastewater in anaerobic sequencing batch reactors, Canadian Agricultural Engineering, vol. 42, no. 3, pp. 131–137.
Edith Padilla-Gasca, Alberto Lopez-Lopez and Juan Gallardo-Valdez (2011). Evaluation of Stability Factors in the Anaerobic Treatment of Slaughterhouse Wastewater, J of Bioremed Biodegrad.
M. H. Gerardi, The Microbiology of Anaerobic Digesters. Wastewater Microbiology Series, John Wiley and Sons Inc, New Jersey, USA, 2003.
S. M. Gauri (2006). Treatment of wastewater from abattoirs before land application: a review, Bioresource Technology, vol. 97, no. 9, pp. 1119–1135.
Y. O. Bello and D. T. A. Oyedemi (2009). Impact of abattoir activities and management in residential neighbourhoods: a case study of Ogbomoso, Nigeria, Journal of Social Science, vol. 19, pp. 121–127.
Pradyut Kundu, Anupam Debsarkar and Somnath Mukherjee (2013). Treatment of Slaughter House Wastewater in a Sequencing Batch Reactor: Performance Evaluation and Biodegradation Kinetics, BioMed Research International, Volume 2013, Article ID 134872, 11 pages, Accessed from http://dx.doi.org/10.1155/2013/134872.
A. O. Aniebo, S. N. Wekhe, andI. C. Okoli (2009). Abattoir blood waste generation in rivers state and its environmental implications in the Niger Delta, Toxicological and Environmental Chemistry, vol. 91, no. 4, pp. 619–625.
Final report: study to establish a baseline for the biogas project. Sludge Market Structuring Program for poor households in Pikine and Guédiawaye (PSMBV). NATIONAL OFFICE FOR THE SANITATION OF SENEGAL. November 2013.
MAXIME ROUEZ: Anaerobic Degradation of Solid Waste: Characterization, Influencing Factors and Modeling. Doctoral thesis; National Institute of Applied Sciences LYON (2008).
Léa Sigot: Fine purification of biogas for energy recovery in SOFC fuel cell: adsorption of octamethylcyclotetrasiloxane and hydrogen sulphide; PhD thesis National Institute of Applied Sciences of LYON (2015).
EMANUEL ADLER et al; how is organic matter transformed into energy? (2009).
http://nenufar-biogaz.fr/production-de-biogaz-et-temperature/ article on "Composition of biogas and factors influencing its composition" revisited on January 14, 2019.
Matgorzata Meres. Analysis of the composition of biogas with a view to optimizing its production and its exploitation in household waste storage centers. Environmental Sciences. National School of Mines of Saint-Etienne; Jagiellonian University Krakow, 2009. French.
D. KARAKASHEV, D. J. BATSTONE & I. ANGELIDAKI, «Influence of Environmental Conditions on Methanogenic Compositions in Anaerobic Biogas Reactor», Applied and Environmental Microbiology, vol. 71, no 1, p. 331–338, 2005.
IWA TASK GROUP FOR MATHEMATICAL MODELLING OF ANAEROBIC DIGESTION PROCESSES, «Anaerobic digestion model no. 1 (adm1)», Rapport technique, IWA (International Water Association), February 2002.
A. Demuer et al., 'Bioenergetic Conversion', Ed. Lavoisier, 311 p., Paris, 1982.
Document, 'Photosynthesis - Biomass - Energy - Resources and Techniques', Collection of Cahiers de AFEDES, N ° 6, Ed. 1982.
Kalia V. C., Kumar A., Jain S. R. et Joshi A. P.,- Biomethanation of plant materials. Biores. Technoz., 41: 209-212. 1992
Moletta R., - Control and management of anaerobic digesters. Journal of Water Science, 2: 265-293. 1989.
Zinder, S. H. Physiological Ecology of Methanogens. In Methanogenesis, Chapman & Hall. New York, pp. 128-206. (1993).
Ward, A. J., Hobbs, P. J., Holliman, P. J. & Jones, D. L. Optimisation of the anaerobic digestion of agricultural resources. Bioresource Technology, 99(17), 7928-7940. (2008).
Habouzit, F., Gévaudan, G., Hamelin, J., Steyer, J.-P. & Bernet, N. Influence of support material properties on the potential selection of Archaea during initial adhesion of a methanogenic consortium. Bioresource Technology, 102(5), 4054-4060. (2010).
François Perron: Energy potential and environmental gains generated by the biomethanation of residual organic matter in Quebec university environmental training center university of sherbrooke 2010.
David BASSARD Methodology for predicting and optimizing the methane potential of complex mixtures in co-digestion T H È S E Compiègne University of Technology Graduate School of Compiègne February 2015.
B. Lagrange, 1979-'Biomethane, Principles - Techniques - Uses', Ed Edisud, 246 p., 1989.
ENYEGUE MBIA Théophile & KEPCHE SENKOUE Karim study, design and production of a domestic biodigester for the production of biogas: application to pig manure.
Rodrigo A. Labatut Largus T. Angenent Norman R. Scott Biochemical methane potential and biodegradability of complex organic substrates Bioresource Technology Volume 102, Issue 3, Pages 2255-2264 February 2011.
Yves Membrez; Hélène Fruteau de Laclos. Energy valorization (biogas) of used edible oils by codigestion with different waste of agrifood origin. Biomass energy research program. Federal Office of Energy. Final Report February 2002.
Romain Girault, Pascal Peu, Fabrice Beline, Thomas Lendormi and Sébastien Guillaume Characteristics of substrates and interactions in co-digestion systems: a special case of co-substrates of agro-industrial origin Irstea | «Waters and Territories Sciences» Issue 12 | pages 44 to 53 ISSN 2109-3016. March 2013.